REPAIR MAINTENANCE OPERATION OF MOTOR VEHICLES
Volkswagen Passat B6 (from the year 2004)

general info. full specifications. diagnostics. hints. tips. tricks

Home

Volkswagen
	Passat B6
		Operation and maintenance of car
		Engine
		Transmission
		Chassis
		Steering Gear
		Brakes
		Onboard electric
			Overview
			Power supply system
			Lighting
				Removing the lights
				Installing lights
				Adjusting the headlights
				Replacing the lamp beam
				Replacing the lamp beam
				Replacing the parking light bulb
				Removal and installation of servo-leveling, headlamp manufacturer - Hella
				Removal and installation of servo-leveling, headlamp manufacturer - Valeo
				Check headlight adjustment
				Check headlight adjustment via vyverochnogo screen without adjusting the 15 ?�
				Adjusting headlamp with gas discharge lamps
				Adjusting the main headlights with halogen lamps
				Main Headlights with gas discharge lamps
				Replacing gas-discharge lamp
				Removing and installing front turn signal lamp
				Removing and installing lighting in the door mirrors to facilitate landing
				Removing and installing the rear light in the sidewall of the body
				Removing and installing light plate (sedan)
				Removing and installing the license plate light, station wagon (Variant)
				Removing and installing bonnet contact switch
				Removing and installing light switch
				Removal and installation of a regulator-leveling and dimmer buttons and instrument panel
				Removal and installation of a control lamp off the front passenger airbag
				Removal and installation of lighting the glove box
				Removal and installation of a control lamp central locking SAFE function
				Replacement of ceiling lighting front of the cabin
				Removing and installing center console switches
				Removing and installing the main fuse box
				Removal and installation of the switching unit on the left side of the engine compartment
				Removal and installation of the relay unit on the left side of the front panel
				General information on repair electricians of the car
				Repair wire CAN bus
				Broken wire with repair in two places
				Repair of contacts in the connector housing
				Mechanical locking connector housing
				Round contacts
				Flat contacts with asymmetrical locking tongues
		Body
		diagrams

printable version

Removing the lights

Fig. 7.43. Components headlamps: 1 - left-leveling actuator or actuator right-leveling; 2 - a lock ring; 3 - left headlight adjustment servo actuator or right-leveling; 4 - a lock ring; 5 - Cut the body; 6 - cap; 7 - Left lamp beam or right light beam; 8 - fixing bolts; 9 - fixing bolts; 10 - adjusting sleeve; 11 - lamp; 12 - left parking light bulb or right parking light bulb; 13 - cap; 14 - Left light beam or right low beam lamp; 15 - cap

NOTE

Disconnect the mass of the battery is not necessary.

The figures show the removal and installation of the left headlight.

Work on replacing the left headlight of similar works on the replacement of the right headlight.

If the lamp has been dismantled, after the installation of the headlamp must be adjusted.

If the lamp has been dismantled with gas discharge lamps, after installation, you must perform the basic setting of headlights.

Turn the ignition and all electrical consumers and translate the key to position 0 (pre-emphasis).

NOTE

Put the ignition key on the remote control during removal and installation into the vehicle in order to avoid blocking doors and self-activation of the ?�Coming Home / Leaving Home (home Arrival / Departure from the house)."

Fig. 7.44. Mnogoshtekernoe Connect

Unlock and disconnect mnogoshtekernoe connection (Fig. 7.44).

Remove the grille.

Remove the cover of the front bumper.

Fig. 7.45. Fixing bolts of the guide profile

Remove the fixing bolts and remove the guide profile 1 (Fig. 7.45).

Fig. 7.46. The upper mounting bolts lights

Remove the upper fixing bolts lights (Fig. 7.46).

Fig. 7.47. The lower fixing bolts lights

Remove the lower mounting bolts of light (Fig. 7.47).

Remove spotlight from the recess of the body.

« previos page
Lighting

next page »
Installing lights